|
|
Thread Tools | Display Modes |
#1
|
|||
|
|||
Rock Shox parts and Maintenance
Rock Shox parts and Maintenance
I have some older Rock Shox forks Judy XC 1996 pre the one piece type. Two problems - can't get them apart and spare parts. In the manual they say just to unscrew the 6mm bolts from the lower tubes and slide the the forks free of the upper tubes. This hasn't happened is there something I'm missing to dismantle the forks. I have removed the MCU spring from the top of the forks. one side has collapsed completely and the other is in tact. Also need the damper unit Where do I buy parts for these forks? Thanks |
Ads |
#2
|
|||
|
|||
Rock Shox parts and Maintenance
Rob wrote: Rock Shox parts and Maintenance I have some older Rock Shox forks Judy XC 1996 pre the one piece type. Two problems - can't get them apart and spare parts. In the manual they say just to unscrew the 6mm bolts from the lower tubes and slide the the forks free of the upper tubes. This hasn't happened is there something I'm missing to dismantle the forks. I have removed the MCU spring from the top of the forks. one side has collapsed completely and the other is in tact. Also need the damper unit Where do I buy parts for these forks? Thanks Don't waste time and effort,trash them. |
#3
|
|||
|
|||
Rock Shox parts and Maintenance
Rob wrote: Rock Shox parts and Maintenance I have some older Rock Shox forks Judy XC 1996 pre the one piece type. Two problems - can't get them apart and spare parts. In the manual they say just to unscrew the 6mm bolts from the lower tubes and slide the the forks free of the upper tubes. This hasn't happened is there something I'm missing to dismantle the forks. Before you remove the bolts .... tap them with a deadblow hammer (or hammer and a block of wood. Basically, just unthread the bolts at the bottom of the slider three full turns. Then use a plastic mallet or a deadblow to tap on both bolts until the heads are back against the sliders, then finish unthreading the bolts and remove the sliders from the rest of the fork. The damper cart., and neutral shaft are probably stuck to the inside of the slider. I have removed the MCU spring from the top of the forks. one side has collapsed completely and the other is in tact. Also need the damper unit Where do I buy parts for these forks? Good luck finding parts .... If you look around you might be able to find an air cartridge upgrade .... when all else fails ... EBAY R |
#5
|
|||
|
|||
Rock Shox parts and Maintenance
Rob wrote: Thanks Wouldn't it be cheaper, and easier, to just buy a new one? '06 Judy for $99 http://www.cambriabike.com/shopexd.asp?id=19967 '97 Judy http://www.cambriabike.com/shopexd.asp?id=23705 http://www.cambriabike.com/shopdispl...e=1&filter=yes http://www.jensonusa.com/store/produ...+Elite+06.aspx |
#6
|
|||
|
|||
Rock Shox parts and Maintenance
|
#7
|
|||
|
|||
Rock Shox parts and Maintenance
Corvus Corvax wrote:
wrote: Good luck finding parts .... If you look around you might be able to find an air cartridge upgrade .... when all else fails ... EBAY http://www.ekosport.com/ta_intro.shtml CC Thats a good solution thanks |
#8
|
|||
|
|||
Rock Shox parts and Maintenance
CowPunk wrote:
Rob wrote: Thanks Wouldn't it be cheaper, and easier, to just buy a new one? '06 Judy for $99 http://www.cambriabike.com/shopexd.asp?id=19967 '97 Judy http://www.cambriabike.com/shopexd.asp?id=23705 http://www.cambriabike.com/shopdispl...e=1&filter=yes http://www.jensonusa.com/store/produ...+Elite+06.aspx Thanks thats a likely option |
#9
|
|||
|
|||
Rock Shox parts and Maintenance
Corvus Corvax wrote:
wrote: Good luck finding parts .... If you look around you might be able to find an air cartridge upgrade .... when all else fails ... EBAY http://www.ekosport.com/ta_intro.shtml CC Looking at the page seems feasible thanks |
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
CAMPY RECORD PARTS CAMPAGNOLO | aram bayzaee | Marketplace | 0 | November 26th 04 01:12 AM |
Rec.Bicycles Frequently Asked Questions Posting Part 1/5 | Mike Iglesias | General | 4 | October 29th 04 07:11 AM |
aus.bicycle FAQ (Monthly(ish) Posting) | kingsley | Australia | 3 | February 24th 04 08:44 PM |
RBR Retards | hold my beer and watch this... | Racing | 17 | September 4th 03 12:29 AM |
Used Rock Shox | Dinsdale | Mountain Biking | 18 | August 13th 03 03:14 PM |